RW420(HongKong), Corolla E12
[ Pobierz całość w formacie PDF ]
IMPORTANT
WARNING/CAUTION/NOTE
Please read this manual and follow its instructions carefully. To emphasize special information, the words
, and
NOTE
have special meanings. Pay special attention to the messages high-
lighted by these signal words.
WARNING
CAUTION
!
!
WARNING
!
Indicates a potential hazard that could result in death or injury.
CAUTION
!
Indicates a potential hazard that could result in vehicle damage.
NOTE:
Indicates special information to make maintenance easier or instructions clearer.
WARNING
!
This service manual is intended for authorized Suzuki dealers and qualified service technicians only.
Inexperienced technicians or technicians without the proper tools and equipment may not be able to
properly perform the services described in this manual.
Improper repair may result in injury to the technician and may render the vehicle unsafe for the driver
and passengers.
WARNING
!
For vehicles equipped with a Supplemental Restraint (Air Bag) System:
•
Service on and around the air bag system components or wiring must be performed only by an
authorized SUZUKI dealer. Refer to “Air Bag System Components and Wiring Location View” under
“General Description” in air bag system section in order to confirm whether you are performing ser-
vice on or near the air bag system components or wiring. Please observe all WARNINGS and “Ser-
vice Precautions” under “On-Vehicle Service” in air bag system section before performing service
on or around the air bag system components or wiring. Failure to follow WARNINGS could result in
unintentional activation of the system or could render the system inoperative. Either of these two
conditions may result in severe injury.
•
If the air bag system and another vehicle system both need repair, Suzuki recommends that the air
bag system be repaired first, to help avoid unintended air bag system activation.
•
Do not modify the steering wheel, instrument panel or any other air bag system component on or
around air bag system components or wiring. Modifications can adversely affect air bag system
performance and lead to injury.
•
If the vehicle will be exposed to temperatures over 93 °C (200 °F), for example, during a paint baking
process, remove the air bag system components, that is air bag (inflator) modules, SDM and/or seat
belt with pretensioner, beforehand to avoid component damage or unintended activation.
The circle with a slash in this manual means “Don’t do this” or “Don’t let this happen”.
FOREWORD
This SUPPLEMENTARY SERVICE MANUAL is a supplement to SX4 (RW420) SERVICE MANUAL.
It has been prepared exclusively for the following applicable model.
Applicable model:
SX4 (RW420) HONG KONG model
This supplementary service manual describes only different service information of the above applicable model
as compared with SX4 (RW420) SERVICE MANUAL. Therefore, whenever servicing the above applicable mod-
els, consult this supplement first. And for any section, item or description not found in this supplement, refer to
the related manual below.
When replacing parts or servicing by disassembling, it is recommended to use SUZUKI genuine parts, tools and
service materials as specified in each description.
All information, illustrations and specifications contained in this literature are based on the latest product infor-
mation available at the time of publication approval. And used as the main subject of description is the vehicle of
standard specifications among others.
Therefore, note that illustrations may differ from the vehicle being actually serviced.
The right is reserved to make changes at any time without notice.
Related Manuals:
Manual Name
Manual No.
SX4 (RW420) SERVICE MANUAL
99500-80J00-01E
© COPYRIGHT SUZUKI MOTOR CORPORATION 2007
RECOMMENDATON OF GENUINE SUZUKI PARTS AND ACCESSORIES USE
SUZUKI strongly recommends the use of genuine SUZUKI parts* and accessories. Genuine SUZUKI parts and
accessories are built to the highest standards of quality and performance, and are designed to fit the vehicle's
exact specifications.
A wide variety of non-genuine replacement parts and accessories for SUZUKI vehicles are currently available in
the market. Using these parts and accessories can affect the vehicle performance and shorten its useful life.
Therefore, installation of non-genuine SUZUKI parts and accessories is not covered under warranty.
Non-Genuine SUZUKI Parts and Accessories
Some parts and accessories may be approved by certain authorities in your country.
Some parts and accessories are sold as SUZUKI authorized replacement parts and accessories. Some genu-
ine SUZUKI parts and accessories are sold as re-use parts and accessories. These parts and accessories are
non-genuine Suzuki parts and accessories and use of these parts are not covered under warranty.
Re-use of Genuine SUZUKI Parts and Accessories
The resale or re-use of the following items which could give rise to safety hazards for users is expressly forbid-
den:
1) Air bag components and all other pyrotechnic items, including their components (e.g. cushion, control
devices and sensors)
2) Seatbelt system, including their components (e.g. webbing, buckles, and retractors)
The air bag and seat belt pretensioner components contain explosive chemicals. These components should be
removed and disposed of properly by SUZUKI authorized service shop or scrap yard to avoid unintended explo-
sion before scrapping.
*The parts remanufactured under SUZUKI's approval can be used as genuine SUZUKI parts in Europe.
00
TABLE OF CONTENTS
0
Precautions............................................................... 00-i
Precautions ............................................................ 00-1
General Information ................................................... 0-i
General Information ............................................... 0A-1
Engine ......................................................................... 1-i
Engine General Information and Diagnosis ........... 1A-1
Engine Electrical Devices.......................................1C-1
Charging System.....................................................1J-1
Suspension ................................................................. 2-i
Suspension General Diagnosis.............................. 2A-1
Wheels and Tires ...................................................2D-1
Brakes ......................................................................... 4-i
Brake Control System and Diagnosis .................... 4A-1
Electronic Stability Program ................................... 4F-1
Restraint...................................................................... 8-i
Air Bag System ...................................................... 8B-1
Body, Cab and Accessories ...................................... 9-i
Instrumentation / Driver Info. / Horn .......................9C-1
Glass / Windows / Mirrors ...................................... 9E-1
Seats ......................................................................9G-1
Control Systems....................................................... 10-i
Body Electrical Control System............................ 10B-1
Keyless Start System ........................................... 10E-1
1
2
3
4
5
6
7
8
9
10
11
[ Pobierz całość w formacie PDF ]